- Insulated aluminium or galvanised slat
- Openings to 5 000mm wide
- Remote and battery backup available
A roll-up garage door coils into a barrel above the opening instead of running back along the ceiling. In Bronkhorstspruit that suits both ends of the market: the older town garages with almost no headroom, and the farm and plot outbuildings where there is no ceiling to run a door into at all.
Roll-up garage doors we supply in Bronkhorstspruit
- Galvanised steel roll-up doors for durability and low maintenance.
- Aluminium roll-up doors where a lighter curtain suits the opening and the motor.
- Powder-coated finishes matched to the house or the building.
- Single and double widths, built to the measured opening.
Roll-up doors on outbuildings and workshops
A shed or workshop framed in purlins and sheeting has no ceiling for a sectional door to run into, and often no proper lintel either. A roll-up curtain needs only the space above the opening, and the guides can be fixed to a properly braced frame. We quote the bracing where it is needed rather than bolting a door to sheeting.
Roll-up garage doors for low-headroom garages
The barrel needs a few hundred millimetres above the opening and nothing behind it, which makes it the practical answer in the older town garages and leaves the ceiling free for storage.
Manual or motorised
Most roll-up doors are motorised with a tube motor inside the barrel, which also keeps the drive out of the dust. Every one we fit has a manual override, and out here we quote battery backup as standard rather than as an option because outages last.
Dust and the barrel housing
An exposed barrel on a farm building collects dust and, more often than people expect, birds. We box the housing in where the position calls for it, specify sealed bearings, and set a cleaning interval at handover that reflects the environment.
Security on a roll-up garage door
Guide depth, end locks and the bottom rail do the work. A motorised door with a locking drive position cannot be pushed up from outside. On an outbuilding away from the house we specify heavier locking than we would on a town garage.
Insulation and weather
A single-skin roll-up curtain is not insulated, and we say so rather than implying otherwise. Where a building is used as a workshop all day under full sun, an insulated curtain is worth the difference. Where it is a store, good bottom seals matter more.
What a roll-up garage door costs in Bronkhorstspruit
Priced on opening width and height, curtain material, finish, motorisation and travel. We measure on site and the quote is firm.
Common questions
About roll-up garage doors
Very little — the curtain coils into a barrel just above the opening rather than running back along the ceiling. Around 300mm to 400mm above the lintel is usually enough. This is why roll-up doors are the answer in garages with beams, storage racking or a flat roof.
Older ones are. A modern galvanised curtain with nylon guide inserts and a soft start-and-stop motor is much quieter than the rattling doors people remember. Most of the noise complaints we are called out for turn out to be dry guides or a worn barrel bearing.
Not to the standard of an insulated sectional door, because the slats have to curl. We improve it with foam-filled slats and heavier perimeter sealing, which helps with dust and noise more than heat. If the garage is attached to living space, a sectional door is the better answer.
Curtains jumping out of the guides, worn barrel bearings, broken springs inside the barrel, and rust along the bottom rail where the door stands in driveway water. All four are repairable, usually in a single visit.
Related
Also worth a look
Wooden Garage Doors
Meranti, cedar and saligna
Meranti, cedar and saligna garage doors built on a galvanised steel frame and sealed on all six faces before they are hung. Tip-up or sectional, manual…
- Timber on a galvanised steel frame
- Sealed all six faces before hanging
- Tip-up or sectional mechanism
Transparent Roller Shutter Doors
Polycarbonate roller shutter doors that close an opening without closing off the light or the view. Popular for showrooms, malls and service counters.
Commercial Roller Shutter Doors
Town shopfronts and the trade counter
Shutters for shopfronts and trade premises in town, built for daily cycling and a finish that lasts in full Highveld sun.
- Sized to your actual cycle count
- Powder-coated to brand colour